Concrete contractor in Orange, TX - driveways and slabs on a packed base
Advanced Beaumont Concrete is a concrete contractor working in Orange, TX. We pour driveways, patios, sidewalks, pool decks and slab foundations for homes, and parking lots and footings for businesses, starting with the ground under them.
- Licensed and fully insured.
- Free on-site estimates.
- Expect a reply within 1 business day.
Orange houses, lots and the ground under them
Orange sits east of Beaumont on I-10, near the Louisiana line, and the work here runs from family homes to storefronts. The older streets toward downtown have driveways and walks that have been down a long time, some cracked into pieces and some tilted where the dirt gave way, while newer houses farther out call for patios, pool decks and wider drives. Shops and small businesses call us for lots and slabs, the same work we do nearby in Bridge City and Vidor.
Most lots here are low and flat, so water doesn't run off on its own and soft dirt stays soft. On ground like that, the base under a slab and the way it's sloped matter more than anything we do to the top.
Concrete work we do for Orange homes and businesses
When an old driveway has sunk or cracked into pieces, we break it out, pack a new base and pour a drive that sheds water.
A patio off the back door on a flat lot needs a slight fall away from the house, so we set the slope before the pour, not after.
Stamped concrete gives a patio or walk the look of stone or brick, but the pattern only lasts if the base under it is packed right.
Older walks often lift where roots push up or sink over soft dirt, and we replace the bad sections so nobody catches a toe on the way in.
We replace cracked or pitted garage floors on a packed base, with a smooth finish that's easy to sweep and carries a parked truck.
Colored, scored or exposed-aggregate finishes dress up an entry or a patio on the newer houses here, and we pour them over the same packed base.
Where a yard changes height or a flower bed is washing onto the drive, a concrete retaining wall holds the dirt back and gives water a planned way through.
Shops, sheds and add-on rooms need a flat, level floor, so we dig out and pack the dirt the slab will sit on before we set a form.
Around a pool, a deck has to drain away from the water and give bare feet some grip, so we slope it and pick the finish with you.
Front steps that have pulled away from the porch or settled crooked are a trip waiting to happen, and we rebuild them on footings set into firm ground.
On a new house or addition, we build up and pack the pad before steel goes in, because the foundation is the part you can't cheaply redo.
When a building needs more than a plain slab, like piers under a raised floor, we dig, form and pour the foundation to the approved plans.
Business lots here carry delivery trucks, so we pour them thicker and lay rebar, the steel that holds a slab together once it cracks.
Footings carry the weight of a wall, a porch post or an addition down to firm ground, and we dig them to the depth the plans call for.
When a slab or part of a house has settled out of level, raising it back up can save tearing out concrete that's otherwise still sound.
We saw-cut openings for doors and plumbing, trim out damaged sections and cut clean edges where new concrete meets old, so the seam looks planned instead of patched.
Get a written concrete estimate for your Orange property
Send the form and we'll get back to you within one business day to set a time. I'll come out, walk the job with you, and you get a free written estimate with no obligation to book.
(409) 240-0378- Based in
- Beaumont, TX 77702
- Hours
- Mon–Fri: 6 AM–11 PM, Sat–Sun: 8 AM–9 PM
Working in Orange: permits, schedule and price
Permits in Orange go through the city's Planning and Community Development Department, and its Plans and Inspections Division reviews site plans and building plans, then inspects the work against them. Every contractor has to have the permit in hand before work starts, so on a job that needs one, plan review comes before the pour. If your new slab has pipes in it, the plumber pulls a separate permit, and the city requires plumbers to hold a State of Texas license and carry $300,000 in general liability insurance, with proof and ID on file at the Inspections Office.
We're a concrete contractor based in Beaumont, TX, licensed and fully insured, and Orange jobs run the same way they do at home. We look up what the city wants for your job and tell you what we found, then handle the paperwork and inspection bookings when the permit is ours to hold, and we have the work ready before we call the inspector because the city charges a re-inspection fee when a job isn't ready or doesn't pass. The price moves with the size and thickness of the slab, how much old concrete and soft dirt has to come out, and the finish, and the schedule moves with the permit review and the weather on pour day.
What we find under Orange driveways and patios
A lot of the sunken driveways and tilted patios we look at here weren't poured badly on top. The dirt under them was raked level instead of dug out and packed, so it settled and the concrete went down with it. We dig past the soft dirt, bring in base and pack it before any concrete shows up, so the new slab has something firm to sit on.
On a flat lot, water goes wherever the concrete sends it, and an old slab that falls toward the house sends it to the foundation or under the garage door. Before we set forms, I look at where the water runs now and set the slope so the new slab carries it out to the yard or the street.
How a concrete job runs when you call us in Orange
Here's how it goes from your side, from the first call to the walk-through on the finished slab.
- +01
Call or send us the form
Tell us what you want poured or replaced and where, and we'll get back to you to set a time for me to come out. You don't need measurements, just the address and what's bothering you.
- +02
I walk the site with you
I look at the ground, where the water goes and what you want, and you get the estimate in writing. If cost is the worry, ask what each choice adds, and I'll tell you where I'd save and where I wouldn't.
- +03
We sort permits, then pour
If the job needs a permit, we handle the paperwork and inspection bookings, and where the city reviews plans first, the pour waits on that review. Our small crew digs out, packs the base and pours with me working alongside, early in the day, because a top that dries too fast in the afternoon sun turns weak and dusty later.
- +04
Walk the finished job together
We walk the finished slab with you and give you the day you can walk on it and the later day you can drive on it. That wait is curing, the time concrete needs to harden enough to take weight, and it's worth not rushing.
Questions about concrete work in Orange, TX
Do I need a building permit for concrete work in Orange, TX?
You need one for new construction and alterations, which covers a new slab foundation, an addition or a swimming pool. New construction, additions, pools and accessory buildings also need a site plan drawn to scale with the application, and a remodel needs a written scope of work. The city's permit list doesn't name driveways or patios by themselves, so for those we ask the city before we schedule and tell you what they said.
Which building codes does Orange, TX use for new slabs and additions?
The city has adopted the 2021 International codes, including the residential and building codes that plans for a new slab or addition are reviewed against. That's the standard a footing, slab foundation or addition gets inspected to, so it's what we build to.
How do I submit a building permit application in Orange, TX?
You can mail the building permit application to P.O. Box 520, Orange, TX 77631, bring it to 303 N. 8th Street, or email it along with your construction documents. Fees can be paid by phone with a credit card, which adds a processing fee.
How do I find out if my property in Orange is in a flood zone?
Use Forerunner, the flood tool listed on the City of Orange website, which shows the flood-related risk for your property and the insurance requirements that may apply. If your lot is in a special flood hazard area, the city requires an elevation certificate for all work there, so it's worth checking before we plan a slab foundation or an addition.
How much does a new concrete driveway cost in Orange, TX?
You get a written price after I've walked your site, and on a driveway here most of the gap between two bids is usually the ground work under it. The base is the first thing people want to trim because nobody sees it, and it's the last thing I'd cut, since a nice finish on a sinking slab is still a sinking slab. If you need to save, a plain broom finish, the light texture that keeps shoes and tires from slipping, costs less than stamped or colored concrete.
Will my new concrete driveway in Orange crack like the old one?
It'll probably crack somewhere, and I'd rather tell you where than pretend it won't. We cut control joints, shallow grooves that give the slab a straight place to crack, early enough that the cracks land there, and the packed base under it gives the pieces firm ground so they don't sink apart the way the old ones did.
Tell us about your Orange concrete job
Describe the project when you call (409) 240-0378 or fill out the form, and I'll come out already knowing what to look at.
Beaumont, TX